Ford Powerstroke Diesel Forum banner

transfer case

  1. 6.7 Drivetrain Problems (2011-2016)
    So I'm working on a 2011 f250 and the transfer case is giving me the code P0563. I have tried multiple tests to see where it's getting "high voltage" however everything is within specs. I can shift in an out of 4h and 4l when ignition is on but engine off but as soon as I turn the engine on it...
  2. 6.0L Problems Forum
    the other day i lost reverse then couldn’t hold park, but it had forward gears and then trying to bring it home i lost all forward gears just curious if anyone knows what happened.
  3. 6.7 Drivetrain Problems (2017-2019)
    So, pulled my camper for the first time since recently having a bds 6” kit installed, including indexing the transfer case. When decelerating or braking, I’m getting an loud “click” or “clunk” that I can also feel slightly. It feels almost like the transfer case is slipping a link or gear trying...
  4. General 6.0L Discussion
    I have heard that the Royal Purple Synchromax is a pretty good fluid to run so I was thinking about buying that, but after looking at it, I noticed that it is a manual transmission fluid. ATF is the "correct" fluid to use, but is using an MTF okay? Also, any other recommendations for a transfer...
  5. 94-98 7.3L Problem Forum
    Hey guys - I'm thinking about buying this van. There is a problem though and that is the 4wd shifter to the right of the driver seat. It will be in my way when I transfer to the seat because I an a quadriplic and the seat needs to spin so I can get in it. My question: Can the shifter be...
  6. 6.0 Drivetrain problems
    2004 F-350 SRW, auto trans, crew cab, long bed I have a grinding/whirring noise somewhere in the front drivetrain. It sounds like it's right below my feet and it gets louder the faster I go. It's not a heavy clunking or a vibration, it honestly sounds like someone used sand instead of grease on...
  7. 99-03 7.3 Transmission Problems
    I have a 1999 (early) F-250 w/ 7.3L, 4WD. truck has 115k miles, I believe NP273 TC When in 4 low and under certain conditions, mostly when downshifting to control speed going down hill (no throttle), the TC will pop or slip out of 4L and I will then be in neutral. No issues that i recall when...
  8. 99-03 7.3L Powerstroke Problems
    Truck is a 2003 F350 4x4 SRW CCSB 7.3L I understand my vacuum lines are irrelevant. It's my transfer case, the t-case motor isn't actuating the 4wd, and I'm also not getting any dash lights. (Dash lights do come on when starting truck) Now I have taken some action on trying to get this thing...
  9. 6.7 Drivetrain Problems (2011-2016)
    Have been having a recurring, but intermittent sound which seems to be coming from the undercarriage. Vehicle: 2015 F-350, SRW 6.7L V8 Diesel 6-Spd Auto trans. Crew cab/short bed. approx. 12k miles, sound first appeared around 5k miles - was careful to not tow trailer until close to 1,500 miles...
  10. General 6.4L Discussion
    Hello Guys, I'm new to this forum and new to Fords. Bought a 2009 F250 about a month ago and tested out my 4x4 yesterday and all is not peachy. I put up my truck on jack stands to see what would happen when using the 4x4 knob. 1st test with the hubs in the unlock position I spun the front...
  11. 6.0 Drivetrain problems
    Ok so I just bought a 2004 F-250 6.0 with ESOF 4WD. The 4x4 indicator light is on and won't turn off. I have replaced the Pulse Vacuum solenoid, replace vacuum hoses to hubs and ensured that the vacuum pump is working. With the key in the on position I can hear the transfer case motor shifting...
  12. General 6.4L Discussion
    It's about that time. Since I don't know when every fluid was changed on this truck, I've decided it's time to change most of them. Last month I swapped out the oil filter, oil, air filter, and fuel filters with new Motorcraft ones. I also cleaned and replaced the water separator. It showed...
  13. Exterior Parts
    I need: an NV271 transfer case (31 spline for an '02 model automatic), both left side doors, shells only are fine, left fender, left inner fender that ties into the core support, left headlight fiberglass piece, left hood hinge, hood lift cylinder, chrome rear bumper, and tailgate...
  14. Performance & Drivetrain Parts
    I have a transfer case that came off a 04 Superduty. It has about 35,000-40,000 miles on it. It was working when it was pulled. Thought mine was blown up and bought it but came to find out that mine was working fine and just had some wires sheared off. It has the shifter motor on it and was...
  15. WANTED
    Just like the title says, looking for a 273 transfer case for a 2003 F-250, Automatic, 5 spd, ESOF. Preferably something within a 3 hour drive from Hampton Roads area in Virginia. I'll come pick it up. Let me know what you have and how much
  16. 94-98 7.3L Problem Forum
    hello everybody im new here. i have a 1995 f250 4x4 stroker. i have tried shifting the truck into 4x4 recently and the transfer case just wont engage. the truck is a 5 speed and manual transfer case with shifter on the floor. any help would be appreciated thanks
  17. General 6.0L Discussion
    I noticed the other day, after my injectors stop clicking, there was a humming/running noise, so upon further looking, I saw the vacuum pump running, doesnt shut off, this never happened till after the dummy plugs were fixed. I may have possibly nudged the connector and plugged it "back" in...
  18. Performance & Drivetrain Parts
    Found this listing on Craigslist. Its located in Arkadelphia, AR. It might be a good deal for someone. $450 for transmission and T-case $250. 1999 Ford Powerstroke Transmission Phone # 501 722 7574
  19. 99-03 7.3 Drivetrain Problems
    '01 F-250 SD XLT 7.3ℓ 4x4 While in 2WD and slow speeds, Drive over a bump and a vibe starts coming from the front end. The ways I have found to stop the vibe is to: Engage 4HI, stop, or hitting another bump works sometimes. This does not happen while in 4HI. Could this be the 4WD driveshaft...
Top