Ford Powerstroke Diesel Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 33 Results
  1. 6.0L Problems Forum
    Hello, i’ve got a 05 f250 with a 6.0 which has an odd intermittent no crank issue. the truck will start and crank first thing in the morning, but if i turn the truck off and change the tune or run the truck in accessory for a few minutes the truck will not crank again. Whenever the truck does...
  2. 6.0L Problems Forum
    Having an issue with my 2003 F250, 250k miles. Colder weather came and the starting system has been having issues. First it was batteries, which they were older so I replaced both and cleaned up the connections since they had plenty of corrosion. Then yesterday I woke up to use my truck, which...
  3. General 6.0L Discussion
    This is my first post on the site, and I wish I had good news. Unfortunately, I don’t. I have some issues. They are as follows- Batteries only reach 13.4 volts while running. Starter barely has enough to start truck, even immediately after shutting down at temp. Batteries tested GOOD at...
  4. 6.0L Problems Forum
    I have a 04 6.0 Ex. Intermittent no crank when the truck is hot. Hasn’t happened cold yet. Turn the key and some of the dash lights turn off. Stereo and check engine light stay on. If I wait a little bit it will crank right up. No codes. Don’t think it’s the park switch. I’ll not crank in...
  5. 99-03 7.3L Powerstroke Problems
    I'm on my third start now, duralast golds have a life time warranty so thankfully I'm not out any money but it's still annoying. The first starter I replaced was old, might have even been the original but I can't be sure, I just replaced that one in March, and now in June I've replaced the one...
  6. 6.0L Problems Forum
    I own a 2003 f250 6.0 with a 06 6.0 diesel when I was driving I lost all electronics and gages when I got home I turned the truck off and when I tried to restart it it sounds like my batteries are dead with the click-click clicks I come back an hour later and try to restart it and fires up...
  7. 6.4L Performance Parts Discussion
    Just bought a 2010 F-250 6.4 New batteries and starter Cleaned all connections at batteries chassis. Barely cranks over Please help
  8. 99-03 7.3L Powerstroke Problems
    hello, I just installed a new starter in my truck and as soon as you connect the negative cables to the battery it starts to crank over. Any idea of what this could be?
  9. 6.4L Problems Forum
    2008, 250, 6.4L Lariat, short-bed, 4x4, crew cab Went to grab lunch and then came back home and parked. The next day, I come out and tried to start the truck but it just made a loud whirring sound. I tried again and same thing happened. The whirring sounds like the starter motor is attemping...
  10. 6.0L Problems Forum
    2005 6.0 super duty. I did a 6.4 starter swap on my truck about 5 months ago. Today I went under to degrease the oil off the starter and heads. After I did that and washed it my starter started making electrical shorting noises/sizzling noise and slightly smoking. Mind you the truck was powered...
  11. 99-03 7.3L Powerstroke Problems
    I have a 2002 f250 7.3 psd. Yesterday after driving to the gas station, the truck would no crank no start, and still is. My ignition switch is ok. I think my small red wire that comes off the starter comes up into the engine bay, but mine isn’t attached to anything. I believe that’s my issue. It...
  12. General 6.0L Discussion
    Hello, I managed to light my starter on fire. I guess everyone says "get your remote start professionally installed" for a reason! >:) I managed to put the fire out with a fire extinguisher I had in the house but, upon removing the starter, I see this orange wire above it that looks to have...
  13. 99-03 7.3L Powerstroke Problems
    OK, what appears to be my OEM starter has finally bit the big one, so I'm looking around for a high torque, gear reduction type. Well, as most of you know, the OEM starter has 3 bolts/holes. But the high torque variety that I've seen for the most part only have 2. Also, the nose is slightly...
  14. 99-03 7.3L Powerstroke Problems
    Okay everyone, I am in need of your expertise. I apologize upfront for the lengthy explanation below. A couple days ago I tried to start my 02' F-250 7.3 with an automatic transmission and got no crank and no start. It sat for 5 days before this without being started and the temperatures here...
  15. 6.0 Motor problems
    Hello everyone! First post, but probably not the last. ;-) I'll TRY to be brief. 2004 f-250 4x4 6.0 Auto /Studded heads/Livewire TS I just bought the truck...actually, I've signed my part of the papers but my wife signs her part in a handful of hours as of this post. 1. When I brought...
  16. 6.7 Motor Problems (2011-2016)
    Batteries seem to hold a charge, they were at 11.5 volts this AM after sitting overnight. The starter engages, then drops out immediately. No solenoid chatter like you would get with bad batteries. Sometimes it will engage, then disengage, then engage again, like you were just tapping the...
  17. 6.4L Problems Forum
    HI, Tonight my 08 F250 would not crank after I made a quick stop at NAPA. Relay on the fuse block clicks, but the starter will not crank. Disconnected the Brown w/green stripe wire next to the battery and jumped it to the battery and it starts up, so the starter is okay. Do any of you have any...
  18. 6.0 Motor problems
    A friend has a 2007 E350 super duty van with the 6.0 power stroke diesel. One of the starter bolts fell out and he needs it replaced asap as he needs the truck for his job. This is Saturday and the dealer is closed. Does anyone know offhand what the size of the bolts are for that starter? Thanks.
  19. Engine 911
    First let me say thanks for the info over the years. Read a lot but never posted before. 04 F-250, 6.0, Single Cab, 4x4, 120k miles. Driving last night and about a mile in my ABS light comes on and no radio power. Then I notice that I have no gauges. Turn around to head back home and the...
  20. 99-03 7.3 Motor Problems
    So when I go to start my truck every once and a while it will make a nasty grinding sound. Long story short there are 4 different spots where some teeth are worn out of the fly wheel. My question is, should I replace the whole fly wheel or just do the ring gear. And if you guys have any input...
1-20 of 33 Results
Top