Ford Powerstroke Diesel Forum banner

problem

  1. Accelerator Position sensor problem HELP!!!

    6.7 Problems Forum (2017-2019)
    I got into a weird problem when trying to install a pedal commander on my truck today. Long story short, I had went outside to install the pedal commander. I went and located the wire harness that plugs into the Accelerator position sensor on the actual pedal attached to this box right above...
  2. Early 99 7.3 Shut off while driving, now doesnt want to start

    99-03 7.3L Powerstroke Problems
    Truck is an early 1999 F250 Super Duty ext cab long bed, ZF6 swap. 164k miles on the dash, has the newer injectors and hpop from what I was told. It does have a 6 position switch, I typically keep it at the daily 70 horse gain tune. I do not beat the truck often. I don't tow often either...
  3. 2016 350 brake oddities

    6.7 Drivetrain Problems (2011-2016)
    So this one I've searched for and nothing seems to fit. Brand new 2016 FX4 package 350. At about 1400 miles commuting home suddenly the left front break grabs a few times (10-15 times in 20 miles). Pulls the wheel to the left a little, get a small pulse in the pedal, but this happened when...
  4. 1999 7.3l E350 Crank no start! need help

    99-03 7.3L Powerstroke Problems
    I currently own a 1999 E350 7.3l powerstroke. The Van has 206,000 on the clock and I received the van while it was not running. The van cranks and does have smoke out of the exhaust while doing so. So far the only things I have replaced is the CPS, IDM and both batteries. When I first got the...
  5. 2001 F350 CCLB fuel economy issue

    99-03 7.3 Motor Problems
    Hi, Just signed onto the forums, I just bought my first PSD after owning my IDIT for a year, a 2001 F350 Crew Cab Longbed Lariat 7.3, 2WD. 158,000 miles. Nabbed it for 7 grand. It has a 2" leveling kit, muffler delete, and an older 4 position DP tuner. I've been noticing the fuel economy is...
  6. Glowplug Problem

    6.0L Problems Forum
    2005 Ford F350 6.0, truck is from texas last winter, has 221k on it. I have a problem with what I think are my glow plugs. Outside temp at 20F or below truck will crank over but not start, white smoke from truck, a shot of starting fluid and it will start. Above 20F it will crank for 20...
  7. 7.3 Stutter

    99-03 7.3L Powerstroke Problems
    So with in the last couple moths or so I have notice my truck like stutters when I'm driving it. Its like someone is patting the throttle and the truck will jerk a little bit. It does it more when I'm just cruising at like 35 or 40 MPH but on the interstate it doesn't seem to ever do it. Not...
  8. A/C Quit - Would love some advice

    6.7 Problems Forum (2011-2016)
    Drive to work and the AC works great. Drive to lunch and no AC at all - just blowing warm air. Strangely, the air coming out isn't humid. This is my first diesel and I've only had it four months so please dumb it down for me. As far as I can tell, the fan doesn't kick on at all. At any...
  9. F250 Driveshaft noise after 6" Lift?

    Suspension & Steering
    Hello all, I've just installed a Rough Country 6" Lift on my 2006 6.0 F250 single cab 4x4, I have also stacked a 2.5" leveling kit along with it (This is my first time lifting a vehicle and first time posting on this forum so I hope I am in the right place. Sorry if I'm not.) . Driving around...
  10. Something draining batterys....hmm

    6.0L Problems Forum
    Well my 06 KR is being a you know what lately. We all know how they can be lol. I have an Edge Insight Cts monitor and i noticed when i was getting in my truck the monitor was already on. I though hm thats weird. Truck started just fine battery voltage was around 13.4 ish. I worked at the fire...
  11. High Idle Issue?

    6.0 Motor problems
    I just wired up the high idle mod for my late '03. Setup is clean and looks good. Recently though, I've had a strange issue happen when the switch is flicked on. The rpms slowly climb to 1200 but "surges" ( not sure if correct term). The rpms quickly jolt down to 1000-1100 briefly then bounce...
  12. Turbo and hpop failure

    99-03 7.3 Motor Problems
    No one in the obs forum is responding, and I know a few of you guys will know... I ran across a deal, its a 97 7.3 that needs a turbo and hpop. He says his uncle had it hooked to a snap on scanner and there is no oil pressure coming from the pump. He also says the turbo is shot the air filter...
  13. HPOP and Turbo Failure

    94-98 7.3 Motor Problems
    I ran across a deal, its a 97 7.3 that needs a turbo and hpop. He says his uncle had it hooked to a snap on scanner and there is no oil pressure coming from the pump. He also says the turbo is shot the air filter sucked up into it. Any ideas on how to test these on site without some good...
  14. 7.3 Wont Start Help!!

    99-03 7.3L General Discussion
    Ok so I have a 1999 F-250 7.3 with roughly 140,000 miles on it. The other day I parked the truck and stupid me left the lights on and it killed the battery. I got a buddy to help me jump start the truck but for some reason it took a really long time and lots of cranking, so I though maybe the...
  15. Possible new powerstroke owner

    Introductions
    Hey guys I have been on the forum for a while but the truck I was going to buy fell though. I ended up with a 08 Duramax with full deletes:doh:. I have liked the truck but something has always felt weird about driving a chevy. I recently found a 2008 Ford F-250 XLT 6.4 with 4000 original miles...
  16. 7.3 Problem Solution Chart

    99-03 7.3 Motor Problems
    Okay guys, I have been trying to learn all of the problems and solutions, well probable solutions, and I thought it would be awesome if someone made a chart or something like such that shows the problem and solution or possible solutions, like the following: Fuel in...
  17. High idle

    H & S Performance
    So I purchased a h&s minimaxx this morning and programmed it on the spot everything went smooth great power and tranny shifts. I drove it around for a while and before I turned it off I let it idle to cool it down before I shut the motor off. It idled like it always did before the tune around...
  18. 7.3 power loss

    99-03 7.3L Powerstroke Problems
    I have a 2002 F350 7.3 that has lost its git up. I can hit the gas and its like I'm pulling something. There isnt any noises. Although a few weeks ago I thought I hurd a short grinding noise from the Turbo when I got on it pulling onto the hwy. Takes forever to get up to speed, boost is about...
  19. 7.3 power loss

    Introductions
    I have a 2002 F350 7.3 that has lost its git up. I can hit the gas and its like I'm pulling something. There isnt any noises. Although a few weeks ago I thought I hurd a short grinding noise from the Turbo when I got on it pulling onto the hwy. Takes forever to get up to speed, boost is about...
  20. Blowing boost tube

    6.4 Motor Problems
    Hey guys so I keep on blowing off my hot side boost tube. Ill put it back on, then within a mile it'll blow right off again. I've cleaned it many times and it doesn't help. Any ideas? It has a dent on the bottom right side of the tube. I thought it came like that normally, but idk. Is that...
Top