Ford Powerstroke Diesel Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-13 of 13 Results
  1. 6.0 Motor problems
    2004 F-350 6.0 CC/LB with 48,000 miles. Engine is almost completely stock, not bulletproofed (sinful, I know). I'm throwing a P0528 code and my fan is running 100% of the time now. It was intermittent for a couple days but now it's happening all the time. It's only about 30-40 degrees up here...
  2. 94-98 7.3L Problem Forum
    Why does my fan turn in the wrong direction and cause my truck to overheat? 1995 Ford F350 7.3 turbo direct injection
  3. 6.7 Problems Forum (2011-2016)
    Blower Control Module (Blower Resistor) Replacement DIY - 2013 F350 XLT XTR I tried searching for information but I couldn't find much on how to replace the blower control module without have to disconnect the AC or heater/radiator hoses. Below is an explanation on how to do it in your garage...
  4. 6.0 Motor problems
    So I have a 2003 6.0 powerstroke with a sinister EGR delete. I have an SCT livewire with custom tunes and every other mod in my sig. I figured by this point I should know exactly what's up as I've done 80% of the mods myself. The problem with my truck right now is my fan speed. I know with a...
  5. 6.0L Problems Forum
    My truck was making a chirping noise and it sounded like a belt slipping but it was very faint (I could barely hear it over the engine). I ran the codes on my scanner and the only one that came up was P0528: fan speed sensor no signal. I had my fan clutch replaced about a month ago due to it...
  6. 6.0 Motor problems
    04 6.0, My fan constantly runs and sounds like a windmill running down the road and killing my fuel mileage and power. I have just replaced the bad egr cooler with a delete kit, oil cooler, water pump and fan clutch. THe only thing i havent replaced is the thermostat. After fixing all the stuff...
  7. 94-98 7.3L Performance Parts
    Im considering doing the whole 6.0 fan on the 7.3 clutch. Is it a drop in install or would I have to get a new shroud or do any other work other then swap the blades?
  8. 6.0L Problems Forum
    Im new to forum but fairly familiar with Ford diesels. I have a 04 6.0 4x4 CC Lariat with headstuds, EGR delete, superchips tune, and straight pipe 3.5" exhaust. I DO NOT TOW. First issue: Theres a weird fan noise that I get every now and then when going through 1st and 2nd. It sounds kind of...
  9. 6.0 Motor problems
    Hey all, been chasing this problem a while so im putting to you pros for some advice, I thank you in advance for your input! I have 04 F350 DRW. Having a problem with it getting hot when I go up grades and it is more pronounced when pulling my toy hauler. What I notice is this, the fan will...
  10. 6.0 Motor problems
    So here's the deal. Did an EGR delete. Installed a sinister diesel coolant filter kit. Did 2 restore plus and 2 restore cleansing cycles, with about 3 distilled water flush cycles. Replaced my thermostat just in case. Haven't replaced my clogged oil cooler yet (25 degree EOT/ECT difference)...
  11. 99-03 7.3L Powerstroke Interior Discussion
    Been reading up on this and none of the solutions seem to fit my problem. '99 F350, 7.3, crew cab, long bed, 299510 mi On very cold mornings the heater works fine for about 15 minutes. After everything gets warm the air flow slowly slows until I stop getting air movement from the vents. I...
  12. 99-03 7.3L General Discussion
    I have over heating problems!!! I have a 2000 F350 4x4 that i purchased about a year ago. The truck has about 280K miles on it and i have already flushed the cooling system once. I have had no issues until around june of this year i noticed that when i pull my dinky little work trailer (6'X8')...
  13. 6.0L Problems Forum
    I was towing my 5th wheel the other weekend and noticed that my fan kicked in only once on the whole trip (including several long climbs where the truck temps were in the 230+ range). So I checked it with AutoEnginuity and it isn't responding to my commands to turn it on. Are there easy ways to...
1-13 of 13 Results
Top