Ford Powerstroke Diesel Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-19 of 78 Results
  1. 99-03 7.3L Powerstroke Problems
    Just pulled into dennys, o/d light was flashing so turned it off after idling for a bit because i dont know whats wrong. Had the windows down for air. Kids ate some wendys and when we were ready to go inside and get food for me and the wife i turned the key to roll the windows up. Volt meter...
  2. 99-03 7.3L Powerstroke Problems
    So I bought an 03 Excursion. ABS light on when I got it. Code was showing both front wheel speed sensors. I replaced them both with Motorcraft. I then did a complete brake, rotor, caliper replacement all the way around along with stainless brake lines. ABS light never went off (except the short...
  3. General 6.0L Discussion
    I'm getting a 2005 Excursion with a 6.0L to use as my hunting rig. Carrying dogs and equipment for upland bird hunting. Details TBD, but planning to set it up for modest offroad capability as most driving will be long distance hwy.
  4. 99-03 7.3L General Discussion
    I recently purchased an 03 Excursion. I had not driven one before. Previous owner had rebuilt engine and transmission and there are a lot of performance parts. I was told he did a lot of towing and trans was built for that, but I was disappointed to see that highway traveling no trailer she is...
  5. 99-03 7.3L Performance Parts
    I just installed this new wastegate with a billet turbo wheel from RiffRaff, along with a non-EBPV pedestal. Runs great with the exception of WOT at highway speeds. Boost will kick up to 25PSI then blow off and hold at 10PSI. Is this normal? I'm afraid I'm going to hook up my 30' camper and not...
  6. 6.0L Problems Forum
    hi, this issue started after I installed a blue spring kit last June. After installing the spring kit and no. 4 and 6 injectors, I drove to N.H. and the excursion started having trouble on hills. Lack of power and stumbling. I had fueled the truck in Maine from a 275 gallon tank that was...
  7. Powerstroke.org Builds & Projects
    Gotta have a build thread right? Here we go! Current Status: Stock and filthy... Truck Info 2002 Excursion XLT 7.3L 4x4 4R100 aka: Bertha, Big Betty White, The Bus, Large Marge History Purchased 03/22 private party with 270k miles, 4th owner Clean Title and dealer maintained until...
  8. Want to Buy FA1759 or PCIS73

    Performance & Drivetrain Parts
    I'm a new member here but not new to forums or even BST on forums. I'm looking for the Ford FA1759 or Donaldson PCIS73 intake for my 7.3 Excursion. All retailers online are on backorder with no estimated shipping date. I don't even know if these things are still manufactured. I currently have...
    $1 USD
  9. 99-03 Ford Excursion Forum
    Ordered an AFE Momentum intake for my late '02 Ex, with 7.3. Went to install today, and the battery cables seem to be fighting me when I try to get the new airbox installed. Come to find out, the cables are routed and set up completely different from the pictures on their website. I went and...
  10. General 6.0L Discussion
    Hey there, New to this forum, ford ownership, 6.0 ownership, and diesel ownership so any help is appreciated! I did ALOT of research on the 6.0 and Excursions before taking this step and think I found a good deal. Just bought a 2005 excursion from Nevada, very clean with 165k miles. The...
  11. 99-03 7.3L Powerstroke Problems
    I'll try and keep this brief. Couple weeks ago the old 300,000 mi 7.3 started acting up. would fire perfect, then start to buck like it was dragging a cylinder or two. Then it would get warm within a block or so and run fine until I shut it off. Outside temps were 70+ degrees and block heater...
  12. 99-03 Ford Excursion Forum
    I just bought a 2001 Excursion 7.3 and had to put a new engine in it. The week I got it back it died on me while driving. I restarted it and the RPM’s were all over the place. Took it to my shop and they discovered the Engine Control Module is shorting and causing the problems. However, Ford...
  13. 99-03 Ford Excursion Forum
    We are 2/3 through converting a 2002 excursion into a camper. The project snowballed into a much more time and $$ intensive undertaking bc, well, to be honest we were having fun with it: -the original excursion is a black limited and it’s pretty -dually + slight lift -newer engine -owned by a...
  14. 99-03 Ford Excursion Forum
    Details, Questions, Advice, All of the Above . . . ( Many hours researching, printing, and highlighting. . .) 2001 Ford Excursion 4x4 7.3L PowerStroke Turbo Diesel 250k IntroWhat's goin' on, y'all? Don't want to repeat previous topics or post, and will attempt to consolidate all of my...
  15. 99-03 7.3 Transmission Problems
    Hey everyone, Just bought a 7.3 01 Ford excursion a month ago before my move back to Florida from Colorado. Installed the Hydra tuner before we left to help get better performance and had Drive in auto sound install a new head unit. On the drive to Florida we stopped in texas to get gas and...
  16. Introductions
    Flew out to AZ on Friday (9/11) and picked up my first Excursion, its also my first Diesel.. 2005 Ford Excursion Eddie Bauer 6.0L V8 Diesel 4WD THIS THING IS HUGE.. lol.. I'm a Heavy-duty Mechanic Apprentice at a company that solely uses Ford trucks. I'm here to learn and have fun! I love...
  17. 2000 Ford Excursion 4WD 7.3L

    Pulls great with Hydra Gearhead Tuner. New Michelin LT265/75R16 tires, New batteries, New head lamps, New 4WD selector mechanism and recently turned rotors.
  18. 6.0L Electronics Discussion
    Hi all. First post and thanks in advance for your help. I have been working on issues with an Excursion that my daughter acquired and when it came time to inspect the vehicle I realized the horn did not work. I took the wheel well off to access the horns and discovered they did not work, so...
1-19 of 78 Results
Top