Ford Powerstroke Diesel Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 67 Results
  1. General 6.0L Discussion
    I have an 05 F550 4x4 6.0 4.88 gearing on 19.5" wheels- recent studs, EGR/oil cooler work completed, stock intake/turbo/exhaust. It is a flatbed with truck camper about 3200 lbs. Has SCT tuner at low tow setting. Wrench light on dash will come on and enter limp mode until engine shut off and...
  2. 6.0 Motor problems
    Good evening all, we are looking for any ideas for a 6.0 fire truck that is not building boost. So follow along with me for a minute. The intercooler popped so we bought an entire banks cooler kit, pipes, intake horn, intercooler, the whole nine yards. So the truck ran good after we did the...
  3. Diesel Diagnostics
    Got a 06 6.0 all stock has sct x4 and custom tunes has trouble making boost only 5psi at 2krpms and max its gotten to is 10 psi got a p0046 p0470 p0472 cuts out real bad between 2100 and 2800 rpms and dumps coal and stutters through without building boost checked the map hose and ebp tube...
  4. 6.0L Problems Forum
    Ok so I just put new injectors in along with some other maintenance stuff (dummy plugs, standpipes, glow plugs, etc.) when I took the CAC boots and pipes off I noticed that there was coolant in the cold side intake boot. I thought that didn’t look right so got my tiny camera on a stick and stuck...
  5. 99-03 7.3L General Discussion
    Hi Everybody, 2001 F-250, stock 7.3 w/ 4” open pipe and AIH delete. Problem: I only get about 13psi boost. So when I pull a 4000lb trailer I can’t keep the EGT down unless I really take it easy. Doesn’t seem right. New air filter and tightened all intake connections. All OK. No difference. I...
  6. 99-03 7.3L Powerstroke Problems
    Lost all power 4x today. I would be nearing 25mph leaving the neighborhood when abruptly all power cuts out happened twice this morning until warmed up and then twice again this evening till it warmed up, ran fine mid-day. maybe it’s my mind forming patterns but interestingly it seemed to be the...
  7. 6.7 Motor Problems (2011-2016)
    I have search and read as much as I could with no luck. I am hopefully someone can share some wisdom. I have a 2012 f-250 6.7 with 215k miles. Waste gate solenoid was replaced at 205k and the turbo was replaced at 207k. The truck has all the “turbo surge” symptoms. Turbo surges bad enough...
  8. 6.0 Motor problems
    Ok so I've had this issue since I bought the truck and I'm at a loss as to what the problem is. The truck (2007 F250 6.0 Powerstroke) has only ever built around 8-10 PSI of boost (maximum), which is obviously low as every other 6.0 I have driven is capable of surpassing 25 PSI like it's nothing...
  9. 6.7 Problems Forum (2020+)
    I have a 2020 6.7 with 22k flawless miles. Today once I got off the interstate, I had a rather odd issue. Once the light turned green I started out but the truck lugged through the intersection and got stuck in 3rd gear, nearly bouncing off red line. I had to fully left off acceleration to get...
  10. 6.0L Problems Forum
    Need help to diagnose a turbo problem. I have a manual 4x4 2005 f350 completely stock with ~100 000 miles on it. I run revx in rotella t6 5w40, fuel additive and I try to take good care of it maintenance wise. The only "upgrade" that I did to the engine is the blue spring mod as well as going...
  11. 6.0 Mod Help
    Hey guys just wanna start of with a thank you in advance for reading this If anybody can answer my questions I’d appreciate it. To start i am taking my 2005 f250 superduty to get head studded. I’m doing ucf heads with hi rev springs. I wanted to add injectors and a turbo. For the turbo I am...
  12. 6.0L Problems Forum
    Hey everyone I’m at a loss here and I’m hoping I didn’t do something major to my truck. I’m new to powerstrokes and I was looking over the forum and it looked like a lot of people were recommending the blue spring upgrade. I watched a few videos and install looked pretty straightforward. Bought...
  13. 99-03 7.3L Powerstroke Problems
    So I have a 1999 Ford F-250 7.3l. The problem I'm having is as we enter the cold winter months I've noticed a significant loss of power. For example, if I let my truck sit overnight and it drops below lets say 32 degrees Fahrenheit outside, when I go to drive it in the morning and don't let the...
  14. 6.0 Motor problems
    2006 f350 6.0 I've been having all kinds of problems with my hpop system. I replaced the STC,dummy plugs, standpipes, oil cooler, EGR delete, new seals and o rings on injectors, IPR, ICP sensor, EBP sensor, MAP sensor and blue spring kit. Issue #1Truck ran idled great went to drive I had no...
  15. 6.7 Motor Problems (2011-2016)
    Hey everyone! I’m extremely new to this forum. I have recently been having problems with my 2012 6.7 F350. It is deleted and running Rudy’s Diesel tunes on SCT4. That being said. 2 weeks ago the turbo blew. The truck barely would go over 30 and not drive able. Took it to a shop and they...
  16. 6.4L Problems Forum
    Hi everyone. I'm Josh... long time viewer, first time poster. I'm on the road with my family and looking for some help. I drive a 2008 F450 with appx. 235,000 miles on it. Auto trans w/ 4.88 gears. DFF/EGR Delete, aftermarket exhaust (obviously), after market intake, studded and new turbos put...
  17. General 6.7 Discussion (2011-2016)
    Long time listener, first time caller. I purchased a 2014 F250 CC Platinum about a month ago. I have since installed an s&b intake, 5" DP back exhaust, and EZ Lynk tuner with GDP tunes. I keep getting mixed info from GDP in regards to what kind of boost pressures I should be seeing. I peak...
  18. 6.0 Motor problems
    I want to apologize ahead of time because I am going to try to give as much info as possible so if this gets lengthy I will try to makes this easy to read. The Truck; 2005 Ford F350, 4x4 DRW, 6.0, 162.435 miles APR Heads 2016 Oil Cooler replaced with OEM 2016 EGR Delete with puck 2015...
  19. 6.0 Motor problems
    I have a problem with my 2006 6.0. It is absolutely stock except for BP EGR cooler. I blew a charge intercooler tube while I was pulling an enclosed trailer. I changed all the hoses. I really have not towed since then. The hoses have not blown off since but a test drive with no trailer at...
  20. 99-03 7.3L General Discussion
    Hello all, I posted a thread (poll) abut swapping van bodies from a gas to diesel a ways back. That project is still in works but in the meantime I picked up rust free early '99 (built 10/98) E350 for peanuts. Only issues aside from needing a good cleaning was the passenger fuel line rubbed on...
1-20 of 67 Results
Top