Ford Powerstroke Diesel Forum banner
black smoke
1-20 of 20 Results
  1. 6.0L Problems Forum
    Ive seen some others who have ran into the same problem as me but have not had any answers as to why I'm still having this problem. I replaced my fuel filters, the map sensor and hose, the EBPS sensor and tubes, the EGR valve. I only have power when its hot and when i do it still flutters at...
  2. General Diesel Discussion
    Out of nowhere it started bellowing black smoke one day and a loss of power. I noticed that it would run fine when first started until it went to shift then it would start its issue. I would turn it off and back on it and it would be fine again until it went to shift into 2nd. I tried this...
  3. 6.0 Motor problems
    Hi everyone- I'm new here and have run into a problem that makes little sense to me. I have 2003 6.0, 200k Excursion. About a month or so ago it began having trouble getting up hills at speed. It wouldn't downshift and simply strained to get up a hill. I looked into that and figured the EGR...
  4. 6.0 Motor problems
    New to forums, Need help with 2007 F250 6.0 that starts up hard and has low to none boost. The turbo makes a very loud constant pinging, goes away when we unplug the turbo solenoid, so we do know that it is coming from the turbo. We also just cleaned the inside of the turbo and replaced the...
  5. 6.0 Motor problems
    I hope someone can help a girl out! My 04 6.0 was running rough and I knew I had an injector or two sticking...then one morning it was all of a sudden super sluggish off the line and blowing black smoke until it would reach 30-35 mph. After that it would clear out and run ok. Pulled the codes...
  6. 6.4L Problems Forum
    I recently purchased my first diesel truck which is a high mileage (224k miles) 2008 6.4L Powerstroke. After I took it home, roughly a week later the truck went into limp mode. I did some research and found the DPF R+ 4.0 and went ahead and pulled the trigger, I only wanted to get rid of the DPF...
  7. 6.0L Problems Forum
    PROBLEM FIXED READ BELOW: Hello, I am a long time lingerer on this website and it has been very helpful in the past but after several attempts (lots of parts & labor) to fix my 2004 Ford Excursion 6.0L, we still can't figure out what the problem is. Any advice will be very appreciative...
  8. 99-03 7.3 Motor Problems
    I have had this problem a few times and can't seem to fix it so figured I'd ask and see if anyone on here does. -no boost -loss of power -exhaust temp raises easily -sort of an air leak near turbo - there has been some oil in coolant tank but none in dipstick. - if I put 140hp on it dumps black...
  9. 6.0 Motor problems
    2004. On a load going up a hill the engine seems to cough. When the load drops off and I accellerate again I have no power at all. After a few seconds and I hit the peddle a few times power returns and I get a huge cloud of black smoke.
  10. 6.0 Motor problems
    I have a 2006 6.0. All stock. Started it up the other morning (~80 deg F) and it immediately started idling rough, almost to the point of stalling though it never stalled. Also blew black smoke, mostly on acceleration. Pulled it around back and checked the obvious things. EGR was clean and...
  11. 6.0 Motor problems
    I have and 05 f250 which has recently been acting up. It won't start, it just roles over and and sputters and spits out blackish grey smoke. The problem started a week ago and I couldn't get it started. After waiting a few hours I was able to get the truck started and it ran halfway decent...
  12. Engine 911
    Hi I have a 03 f250 6.0 2 weeks ago had extreme power loss changed fuel filters and icp sensor was showing bad so it was changed to. took it for a drive shortly after started blowing extreme amounts of smoke. This happens at idle no smell of coolant in the exhaust. unplugged icp sensor did not...
  13. 6.0 Motor problems
    I was having problems with after down shifting back down to around 2000 rpms it has a hard time getting past it and will black smoke a lot so i pulled the egr a cleaned it i did have to replace one of the O-rings and had to re-tap one of the holes that the bolt goes in the code for the EGR is...
  14. 6.0L Problems Forum
    Hello All, I have a new problem with my truck and need some advice on what exactly to TELL the dealership to do to make some preventative changes instead of just applying band-aids. My Truck: 2006 F250 4x4 SD 6.0. 60,000 Miles. No mod's other then level and 35's. No Heavy Towing. My...
  15. 99-03 7.3 Motor Problems
    truck idles at a really rough lope almost liike its going to die, but accelerates faster than with my program and is blowing a lot of black smoke. i just put a new computer in it and recently put a new turbo in it
  16. Trucks
    I have for sale my 1999 Ford F350 7.3l 4x4 dually crew cab long bed with a 2.5" leveling kit, 16" black rockstar rims with 315/75/16 toyo m/t's, 2" rear wheel spacer, cold air intake, superchip, straight pipe, train horns, 230k true miles. kbb is 12000 im selling her for 11500. im located in...
  17. 6.0 Motor problems
    I have an 05 psd. It has ARP head studs, egr delete, SCT tunes. I just finished installing the stand pipes update, dummy plug update, STC fitting update, injector o'rings, ICP sensor, and the IPR valve in the High Pressure Oil System. Truck took a bit to crank up after breaking the HPO system...
  18. 6.4L Performance Parts Discussion
    wondering what oil to get. want the best mileage synthetic i can get. i have also heard that some oil can make more black smoke??? thanks
  19. 6.4L Performance Parts Discussion
    noticing not nearly as much black smoke with the temperatures dropping. why is this and is that normal?? thanks
  20. 6.0 Motor problems
    I have a 2003 F250 6.0L that I just bought. The heads were off the engine due to engine overheating by the previous owner. I assembled the engine with a new head set. I deleted the EGR. (I figured the EGR valve and EGR cooler was the cause of the heating problem) The engine starts fine and...
1-20 of 20 Results
Top